Back to all

A Door No One Can Step Through (Fuel Door Repair and Maintenance)

September 12, 2021

Your vehicle has lots of doors including that one usually near the back on the vehicle's side.  That's the fuel door, something you use every time you gas up.  These endure hundreds of open-and-close cycles, usually without any problems.  But when they act up, it can be a major inconvenience for you.

When they stick in the "open" position, it can present real dilemma.  You can still pump your gas, but do you just drive around with that flap sticking out the side? What happens if someone steals the gas cap or it gets damaged? What happens if it rains? Yep, it's decision time.

A fuel door that sticks open can be due to a number of factors.  The hinge on the door may have broken, possibly from corrosion or it may have been hit sometime.  Some vehicles have a cable that operates the door and it could be loose.  The latch that holds the door shut could have broken or it, too, could be bent from something hitting it. 

You probably want to take care of this sometime soon since your gas cap is wide open and unprotected when the door doesn't shut.  Plus, it's possible that the door could be torn off completely.  Often a stuck open fuel door can be fixed fairly inexpensively and quickly depending on the type of mechanism your vehicle has. Looks like it's an open and shut case.

Tuffy Tire & Auto Service Center Grove City
2131 Stringtown Road
Grove City, Ohio 43123
614-871-4020
http://www.tuffygrovecity.com

More articles from Tuffy Grove City

A Not-So-Straight Story (Vehicle Pulls to One Side)

September 14, 2025

A vehicle should travel straight down a straight road with the steering wheel centered. But time and travel can take their toll and soon you may find your vehicle pulling to the left or right. Those are not good signs and should be taken care of fairly quickly. One thing that you should note is... More

That Vexing Vapor Venting (Vapor Coming out of Vents)

September 7, 2025

You may have noticed sometimes on a hot and humid day, vapor will come out of your vehicle's vents when you have the air conditioning on. Is that something to be concerned about? Well, it depends. Sometimes that steam or vapor can be caused by water accumulating in the vent system after it has c... More

How Tired Are Your Tires? (Tire replacement)

August 31, 2025

Of the things you think about most, your tires are probably pretty far down the list. Thats understandable because todays tires are engineered to do their job without needing you to pay too much attention to them. But they DO wear out, and worn tires can contribute to skidding in bad weather, not... More